Rock Products - The Leading Voice of the Aggregate Industries.

New Construction Starts Decrease 16 Percent


Nonresidential Building And Nonbuilding Construction Experience Substantial Declines; Highways Up 2 Percent.

By Mark S. Kuhar

 

New construction starts in December retreated 16 percent to a seasonally adjusted annual rate of $568.2 billion, according to Dodge Data & Analytics. The decline follows the 13 percent increase reported for total construction starts in November, when activity reached its highest level in 2014.

Both nonresidential building and nonbuilding construction in December witnessed substantial percentage declines relative to their robust November amounts. At the same time, residential building managed a modest gain in December with the help of further growth by multifamily housing.

The December statistics produced a reading of 120 for the Dodge Index (2000=100), compared to 143 in November. For all of 2014, the Dodge Index came in at 122, so while December was down considerably from the previous month it still held close to the average for the full year.

“The construction start statistics can often be volatile on a month-to-month basis, given the presence of large projects in any one given month,” stated Robert A. Murray, chief economist for Dodge Data & Analytics. “The month of November included four projects valued each in excess of $1 billion, while the largest project in December was a $700 million steel mill. A better sense of the progression of construction starts over the course of 2014 comes from looking at the data on a quarterly basis. Activity weakened during the first quarter of 2014, falling 10 percent from the end of 2013, but then showed steady improvement as 2014 proceeded, with gains in the second quarter, up 9 percent; the third quarter, up 5 percent; and the fourth quarter, up 2 percent.”

Nonresidential Building

Nonresidential building in December fell 23 percent to $196.6 billion (annual rate), following its 32 percent increase in the previous month. Manufacturing plant construction plunged 73 percent, given the comparison to November that included the $2.5 billion lithium ion battery factory for Tesla Motors in Nevada and a $1.3 billion nitrogen urea plant in Oklahoma.

 Monthly Construction Starts (Seasonally Adjusted Annual Rates, In Millions of Dollars) December 2014

November 2014 

% Change
Nonresidential Building $196,595 $256,867  -23
Residential Building $247,263 $239,200 +3
Nonbuilding Construction $124,293 $181,571 -32
TOTAL Construction $568,151 $677,638 -16

While December did include the start of a $700 million steel mill in Arkansas, the next largest manufacturing projects were valued at $70 million or less. The commercial building group in December slipped 5 percent, given a steep drop for hotels, down 34 percent; and much smaller declines for warehouses, down 3 percent; and offices, down 2 percent.

The office category did include several noteworthy projects as December starts, such as the $304 million office portion of a $675 million mixed-use project in Miami, a $191 million office complex in Mountain View, Calif., a $150 million office building in Boston, and a $124 million office complex in Seattle. Store construction in December showed improvement after a lackluster November, rising 10 percent.

The institutional building group in December fell 10 percent. Much of the decline came as the result of a sharp 71 percent drop for transportation terminal work, which had been boosted in November by the start of the $1.6 billion airport terminal redevelopment program in Salt Lake City.

Educational facilities slipped 4 percent in December, although the latest month did feature the start of seven high schools valued at $50 million or more, including a $126 million high school in Irvine, Calif.

Healthcare facilities fell 5 percent in December, despite the start of a $328 million hospital in the Houston metropolitan area and a $143 million hospital addition in Avon, Ohio.

On the plus side, the public buildings category jumped 62 percent in December, with the lift coming from a $168 million prison project in San Diego. Also reporting large percentage gains were church construction, up 41 percent; and amusement-related work, up 40 percent, with the latter being boosted by the start of a $100 million convention center in Casa Grande, Ariz.

Residential Building

Residential building in December improved 3 percent to $247.3 billion (annual rate). Multifamily housing climbed 14 percent, lifted by groundbreaking for two residential towers in New York, valued at $384 million and $275 million, respectively.

Additional multifamily projects in December included $208 million for the multifamily portion of a $675 million mixed-use tower in Miami and $171 million for the multifamily portion of a $200 million mixed-use tower in Boston. Single-family housing in December settled back 1 percent, as it maintained the essentially flat pattern that was present throughout 2014.

Nonbuilding Construction

Nonbuilding construction in December plummeted 32 percent to $124.3 billion (annual rate), following its 21 percent hike in November. A large share of December’s decline was due to a 79 percent plunge for the electric power and gas plant category, which had been boosted in November by the start of the $3.6 billion Dominion Cove Point LNG Liquefaction project in Maryland and a $571 million natural gas-fired power plant in Virginia.

Although December did include a $500 million retrofit of four coal-fired power plants in Alabama, this was not enough to cushion the category’s steep December drop.

New public works projects in December fell a more moderate 10 percent, and reflected decreased activity for water supply systems, down 25 percent; and miscellaneous public works (site work, mass transit, pipelines), down 43 percent.

On the plus side, highway and bridge construction in December increased 2 percent, and included the start of the $555 million Kosciuszko/Newtown Creek bridge rehabilitation project in Brooklyn and Queens, N.Y. Growth in December was also reported for river/harbor development, up 3 percent; and sewer construction, up 6 percent.


2014 Construction Spending

For 2014 as a whole, total construction starts climbed 7 percent to $575.3 billion. This continues the pattern of moderate expansion for total construction starts reported during the previous two years – 2012, up 10 percent; and 2013, up 9 percent.

For 2014 as a whole, nonresidential building climbed 17 percent to $208.2 billion, following the 11 percent gain that was reported in 2013. The manufacturing building category surged 74 percent, lifted by the start of numerous energy-related plants located in the Gulf Coast region of Texas and Louisiana, such as the $3.0 billion Chevron Phillips cracker ethylene plant and the $3.0 billion Exxon petrochemical plant expansion.

If the manufacturing plant category is excluded, nonresidential building in 2014 would be up 11 percent, after an 8 percent increase in 2013 on a similar basis.

The commercial building group in 2014 advanced 15 percent, led by a 28 percent increase for the office category that featured the start of such projects as the $2.3 billion office portion of the $2.5 billion Apple corporate headquarters in Cupertino, Calif., and the $806 million office portion of the $933 million Comcast Innovation and Technology Center in Philadelphia.

The top five metropolitan areas ranked by the dollar volume of new office starts in 2014 were – New York, San Jose, Calif., Houston, Philadelphia and Chicago. The other commercial categories showed this performance in 2014 – hotels, up 23 percent; warehouses, up 18 percent; and stores and shopping centers, unchanged from the previous year.

The institutional building group for all of 2014 increased 8 percent, marking the first gain since 2008. The educational facilities category rose 12 percent, and featured greater activity for these major segments – K-12 school construction, up 18 percent; and college and university construction, up 19 percent.

Increases were also reported for public buildings, up 13 percent; amusement-related work, up 12 percent; and transportation terminals, up 10 percent. The healthcare facilities category in 2014 did not participate in the broad upward trend, as it slipped 1 percent. Church construction in 2014 continued to be depressed, falling an additional 10 percent.

The 2014 amount for residential building was $227.8 billion, up 8 percent, and a much smaller increase than what was reported in 2012, up 31 percent; and 2013, up 26 percent. Single-family housing grew just 2 percent in dollar terms, considerably less than its 27 percent jump in the previous year.

For the full year 2014, nonbuilding construction dropped 6 percent to $139.2 billion, which followed the 9 percent decline reported for 2013. Public works construction overall in 2014 was down 7 percent, sliding back after its 12 percent gain in the previous year.

Highway and bridge construction retreated 15 percent from a very strong amount in 2013 that included several substantial bridge projects, such as the $3.1 billion Tappan Zee Bridge replacement in New York. Declines were also reported for river/harbor development, down 6 percent; and water supply systems, down 7 percent.

Annual gains were reported for miscellaneous public works, up 4 percent (with much of the support coming from increased mass transit work), and sewer construction, up 8 percent. The electric utility and gas plant category in 2014 retreated 2 percent, a much smaller drop than the 55 percent plunge in 2013.

While alternative power generation projects (primarily solar and wind) were down sharply, more traditional power generation plants held steady, and natural gas plants increased with the start of the Dominion Cove Point LNG Liquefaction project.